ZHANG Guoqing，ZHANG Daixin，LI Yunmei，et al. Slurryability of coal water slurry prepared with Jungar coal[J]. Coal Science and Technology，2023，51（S1）：484−490
. DOI: 10.13199/j.cnki.cst.2022-1565| Citation: |
ZHANG Guoqing，ZHANG Daixin，LI Yunmei，et al. Slurryability of coal water slurry prepared with Jungar coal[J]. Coal Science and Technology，2023，51（S1）：484−490 . DOI: 10.13199/j.cnki.cst.2022-1565
|
In order to improve the leaching efficiency of alumina in Jungar pulverized coal ash, the method of applying Jungar coal in the form of coal-water slurry to circulating fluidized bed (circulating fluidized bed, CFB) boiler is proposed, that is, by virtue of the low-temperature combustion characteristics of coal-water slurry, the calcination temperature in the furnace of CFB boiler is further reduced, so as to improve the reactivity of coal ash and the leaching efficiency of subsequent processes. In order to explore the slurry-forming performance and the best slurry-making process of Jungar coal, taking the preparation experiment of coal-water slurry as the main line, the dispersion effects of four common coal-water slurry dispersants, such as NNO, MF, LC and LS, on Jungar coal-water slurry were systematically compared, and the influence of particle size on Jungar coal-water slurry was discussed, and the rheological properties of slurry were analyzed by using rheological data and Herschel-Bulkley model. The results show that the dispersant NNO has the best dispersion effect, and can improve the apparent viscosity and flow diameter of Jungar coal-water slurry from 966 mPa·s (coal slurry concentration 60%) and 9.1 cm without dispersant to 468 mPa·s and 13.2 cm under the condition that the dosage is only 0.4% of the dry basis pulverized coal mass; The particle size has a significant impact on the stability of Jungar coal-water slurry. As the average particle size of coal powderD50 decreases from 47.2 µm to 20.5 µm, the stability of slurry is improved, and the occurrence time of hard precipitation is prolonged. WhenD50≤35.0 µm, the occurrence time of hard precipitation of coal slurry is more than 7 days, meeting the production requirements; The comprehensive performance of coal-water slurry prepared from Jungar coal atD50=35.0 µm is the best. Under the condition of coal slurry concentration of 60%, the apparent viscosity of the slurry is only 639 mPa·s, and the flow diameter is 11.9 cm, and the flow grade is Bˉ Grade, hard precipitation occurrence time <7 days, low calorific value 10.06 MJ/kg, belonging to high-quality coal water slurry; Jungar coal-water slurry shows shear-thinning rheological characteristics, is a pseudoplastic fluid, and conforms to Herschel-Bulkley model, with rheological property index n<1.
| [1] |
DAI S,JIANG Y,WARD C R,et al. Mineralogical and geochemical compositions of the coal in the Guanbanwusu Mine, Inner Mongolia, China: Further evidence for the existence of an Al (Ga and REE) ore deposit in the Jungar Coalfield[J]. International Journal of Coal Geology,2012,98:10−40. doi: 10.1016/j.coal.2012.03.003
|
| [2] |
刘大锐, 高桂梅, 池君洲, 等 准格尔煤田黑岱沟露天矿煤中稀土及微量元素的分配规律[J]. 地质学报, 2018, 92(11): 2368-2375.
LIU Darui, GAO Guimei, CHI Junzhou, et al. Distribution law of rare earth and trace elements in coal of heidaigou open pit mine in zhungeer coalfield[J]. Acta Geologica Sinica, 2018, 92(11): 2368-2375.
|
| [3] |
冀 鹏. 神华准格尔矿区高铝粉煤灰开发利用实现规模化的探讨[J]. 内蒙古科技与经济,2013(23):75−77.
JI Peng. Discussion on the large-scale development and utilization of high alumina fly ash in shenhua zhungeer mining area[J]. Inner Mongolia Science Technology& Economy,2013(23):75−77.
|
| [4] |
WU C,YU H,ZHANG H. Extraction of aluminum by pressure acid-leaching method from coal fly ash[J]. Transactions of Nonferrous Metals Society of China,2012,22(9):2282−2288. doi: 10.1016/S1003-6326(11)61461-1
|
| [5] |
GUO Y,ZHAO Z,ZHAO Q,et al. Novel process of alumina extraction from coal fly ash by pre-desilicating—Na2CO3 activation—Acid leaching technique[J]. Hydrometallurgy,2017,169:418−425. doi: 10.1016/j.hydromet.2017.02.021
|
| [6] |
丁宏娅. 采用改进酸碱联合法从高铝粉煤灰中提取氧化铝的研究[D]. 北京: 中国地质大学(北京), 2007.
DING Hongya. Preparation of alumina from high–alumina fly ash by improved acidand alkali combination method: An experimental study[D]. Beijing: China University of Geosciences Beijing, 2007.
|
| [7] |
杨 静,蒋周青,马鸿文,等. 中国铝资源与高铝粉煤灰提取氧化铝研究进展[J]. 地学前缘,2014,21(5):313−324.
YANG Jing,JIANG Zhouqing,MA Hongwen,et al. Research progress on aluminum resources and alumina extraction from high alumina fly ash in china[J]. Earth Science Frontiers,2014,21(5):313−324.
|
| [8] |
匡敬忠,邱廷省,施 芳. 热处理对高岭石结构转变及活性的影响[J]. 中国有色金属学报,2012,22(1):258−264.
KUANG Jingzhong,QIU Tingsheng,SHI Fang. Effect of heat treatment on structure transformation and activity of kaolinite[J]. The Chinese Journal of Nonferrous Metals,2012,22(1):258−264.
|
| [9] |
徐少南. 准格尔矸石电厂CFB灰特征及综合利用 [D]. 长春: 吉林大学, 2009.
XU Shaonan. Characteristic and utilization study of CFB ash from zhungeer gangue power plant[D]. Changchun: Jilin University, 2009.
|
| [10] |
CHENG S,JIU S,LI H. Kinetics of dehydroxylation and decarburization of coal series kaolinite during calcination: a novel kinetic method based on gaseous products[J]. Materials,2021,14(6):1493. doi: 10.3390/ma14061493
|
| [11] |
KASSA A E,SHIBESHI N T,TIZAZU B Z. Characterization and optimization of calcination process parameters for extraction of aluminum from Ethiopian kaolinite[J]. International Journal of Chemical Engineering,2022,23:1−18.
|
| [12] |
WAN Q,RAO F,SONG S. Reexamining calcination of kaolinite for the synthesis of metakaolin geopolymers-roles of dehydroxylation and recrystallization[J]. Journal of Non-Crystalline Solids,2017,460:74−80. doi: 10.1016/j.jnoncrysol.2017.01.024
|
| [13] |
WANG R,YE X,ZHAO Z,et al. Simultaneous disposal and utilization of coal chemical wastewater in coal and petroleum coke slurry preparation: Slurrying performance and mechanism[J]. Fuel,2018,215:312−319. doi: 10.1016/j.fuel.2017.11.038
|
| [14] |
QIN Z,ZHAI G,WU X,et al. Carbon footprint evaluation of coal-to-methanol chain with the hierarchical attribution management and life cycle assessment[J]. Energy Conversion and Management,2016,124:168−179. doi: 10.1016/j.enconman.2016.07.005
|
| [15] |
DONG X,YANG S,LIU X,et al. Techno-economic performance of the coal-to-olefins process with CCS[J]. Chemical Engineering Journal,2014,240:45−54. doi: 10.1016/j.cej.2013.11.051
|
| [16] |
ANDREASEN A H M J K B. Zur Kenntnis des Mahlgutes[J]. Kolloidchemische Beihefte,1928,27(6):349−458.
|
| [17] |
BOYLU F,DINCER H,ATEşOK G. Effect of coal particle size distribution, volume fraction and rank on the rheology of coal–water slurries[J]. Fuel Processing Technology,2004,85(4):241−250. doi: 10.1016/S0378-3820(03)00198-X
|
| [18] |
LI Q,LIAO C,HOU J,et al. Model to predict packing efficiency in coal water slurry: Part1 construction and verification[J]. Fuel,2022,318:123345. doi: 10.1016/j.fuel.2022.123345
|
| [19] |
张荣曾. 水煤浆制浆技术 [M]. 北京: 科学出版社, 1996: 232−234.
|
| [20] |
张荣曾,刘炯天,徐志强,等. 连续粒度分布的充填效率[J]. 中国矿业大学学报,2002,32(6):8−12.
ZHANG Rongzeng,LIU Jongtian,XU Zhiqiang,et al. Filling efficiency of continuous particle size distribution[J]. Journal of China University of Mining & Technology,2002,32(6):8−12.
|
| [21] |
XIAO Y,YTA B,YRA B,et al. Optimization of packing state in brown coal water slurry based on the two-grade fractal model - Science Direct[J]. Fuel,2016,168:54−60. doi: 10.1016/j.fuel.2015.11.078
|
| [22] |
毛成龙. 三峰级配制备高浓度水煤浆成套技术及工业化应用[J]. 煤炭科学技术,2018,46(S2):259−263.
MAO Chenglong. Complete set of technology for preparing high concentration coal water slurry at three peak levels and its industrial application[J]. Coal Science and Technology,2018,46(S2):259−263.
|
| [23] |
段清兵,张胜局,段 静. 水煤浆制备与应用技术及发展展望[J]. 煤炭科学技术,2017,45(1):205−213.
DUAN Qingbing,ZHANG Shengju,DUAN Jing. Preparation and application technology of coal water slurry and its development prospect[J]. Coal Science and Technology,2017,45(1):205−213.
|
| [24] |
KONDURI M K R,FATEHI P. Alteration in interfacial properties and stability of coal water slurry by lignosulfonate[J]. Powder Technology,2019,356:920−929. doi: 10.1016/j.powtec.2019.09.019
|
| [25] |
孟献梁,王红林,吴国光,等. 聚羧酸系水煤浆分散剂对高灰煤泥成浆性的研究[J]. 煤炭科学技术,2013,41(10):121−124.
MENG Xianliang,WANG Honglin,WU Guoguang,et al. Study on the effect of carboxylic acid based coal water slurry dispersant on the slurryability of high ash coal slurry[J]. Coal Science and Technology,2013,41(10):121−124.
|
| [26] |
JING H, XU J, DONG W, et al. Effects of amphiphilic copolymer dispersants on rheology and stability of coal water slurry [J]. 2013, 52(25): 8427–8435.
|
| [27] |
王淼森. 神华新疆煤制气化水煤浆的成浆性试验研究[J]. 煤炭科学技术,2017,45(4):195−198.
WANG Miaolin. Experimental study on slurry forming of coal water slurry gasification from shenhua xinjiang coal[J]. Coal Science and Technology,2017,45(4):195−198.
|
| [28] |
杨东杰,郭闻源,李旭昭,等. 不同相对分子质量对接枝磺化木质素水煤浆分散剂吸附分散性能的影响[J]. 燃料化学学报,2013,41(1):20−25.
YANG Dongjie,GUO Wenyuan,LI Xuzhao,et al. Effect of different relative molecular weight on adsorption and dispersion of grafted sulfonated lignin coal water slurry dispersant[J]. Journal of Fuel Chemistry and Technology,2013,41(1):20−25.
|
| [29] |
张孝雨. 颗粒形态对水煤浆性能影响的研究[D]. 北京: 煤炭科学研究总院, 2020.
ZHANG Xiaoyu. Study on the influence of particle morphology on the performance of coal water slurry[D]. Beijing: China Coal Research Institute, 2020.
|
| [30] |
郑剑平,刘凯林,薛继峰,等. 吡啶对褐煤水煤浆流变性的影响[J]. 煤炭科学技术,2022,50(8):270−276.
ZHENG Jianping,LIU Kailin,XUE Jifeng,et al. Effect of pyridine on rheology of lignite coal water slurry[J]. Coal Science and Technology,2022,50(8):270−276.
|
| [31] |
王春雨,赵 辉,代正华,等. 基于颗粒表面修饰的高浓度水煤浆制备及其流动性能[J]. 煤炭转化,2020,43(3):57−63.
WANG Chunyu,ZHAO Hui,DAI Zhenghua,et al. Preparation and flowability of high concentration coal water slurry based on particle surface modification[J]. Coal Conversion,2020,43(3):57−63.
|
| [1] | LU Zhaohua, ZHANG Lin. Ecological stability evaluation of revegetation community on open-pit coal mine dump slopes[J]. COAL SCIENCE AND TECHNOLOGY, 2024, 52(1): 334-344. DOI: 10.12438/cst.2023-1933 |
| [2] | XU Wenbin, CHEN Wei, ZHANG Yalun, CHEN Bocen. Research on rheological characteristics of gangue-fly ash slurry in deep filling mining[J]. COAL SCIENCE AND TECHNOLOGY, 2023, 51(3): 85-93. DOI: 10.13199/j.cnki.cst.2021-0444 |
| [3] | ZHENG Jianping, LIU Kailin, XUE Jifeng, LI Gaohui, ZHANG Lifeng, TU Yanan. Study on effect of pyridine on rheological properties of lignite water slurry[J]. COAL SCIENCE AND TECHNOLOGY, 2022, 50(8): 270-276. |
| [4] | ZHU Shibin, WANG Xiaodong, WU Boqiang. Study on time-dependent characteristics of rheological parameters on high-concentration slurry in treatment of coal mining subsidence area[J]. COAL SCIENCE AND TECHNOLOGY, 2021, 49(10): 122-127. |
| [5] | ZHU Shibin WANG Xiaodong XU Ganggang WU Boqiang YUAN Kekuo, . Experimental study on rheological properties of high concentration cementing materials in coal mine goaf filling[J]. COAL SCIENCE AND TECHNOLOGY, 2017, (11). |
| [6] | Fu Xiaolong Peng Yanghao Li Duo Cheng Kun, . Research on impact of water reducing agent for cemented tailing fill slurry conveying property[J]. COAL SCIENCE AND TECHNOLOGY, 2017, (7). |
| [7] | Sun Chuang Xu Naizhong Fan Zhenli Wang Mingli, . Analysis on rational loading time of coal pillar in wedge pillar type goaf[J]. COAL SCIENCE AND TECHNOLOGY, 2017, (3). |
| [8] | Sun Meijie Zheng Jianping Chu Tiancheng Chai Yadong, . Study on dispersant affected to stability of lignite coal water slurry[J]. COAL SCIENCE AND TECHNOLOGY, 2015, (7). |
| [9] | Kang Hongpu Yang Jinghe Jiang Pengfei, . Tests and analysis on mechanical properties for cable bolts[J]. COAL SCIENCE AND TECHNOLOGY, 2015, (6). |
| [10] | ZHANG Jing HE Guo-feng WANG Guo-fang, . Study on Property and Synthesis of Alkali Lignin Dispersant for Coal-water Slurry by High Pressure Homogenization Activation[J]. COAL SCIENCE AND TECHNOLOGY, 2014, (4). |
| 1. |
马志宏，张杨鑫，李培石，许先义，蔡晋，黄中. 超细水煤浆雾化燃烧技术. 洁净煤技术. 2024(S1): 534-541 .
|
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: